灌装机故障警报

故障显示（英文）

Emergency Button PressedLow air PressurePLC CPU Stop

Operator Terminal DisplayPLC-Uniop CommunicationUniop Low BatteryPLC Low BatteryIncorrect PasswordPrinter Not ConnectedPrinter　Error

Flash Cooler Low Level

故障显示（中文）按下紧急停机开关压缩空气压力过低PLC CPU停止显示屏故障

PCL与显示屏通讯故障显示屏电池需更换PLC电池需更换密码不正确没有连接打印机打印机故障闪蒸器液位过低

Sercurity Stop HeadInput Barrier SecurityOutput Barrier SecuritySecurity Gate OpenSecurity Table ActiveTable Sensible Edge

Oil Motors Circuit Breaker安全保护停机入口安全保护出口安全保护门安全开关被打开升降台锁定保护升降台底部安全保护

液压油电机断电开关保护（QM281/286）

Steril Chamber Open

Steril Chamber Low TemperaturePuffing Low Temperature Function Timeout FaultTare Too High AlarmWrong Set-point AlarmOut of Tollerance AlarmIncreasing Balance Alarm

Max Weight on Balance Alarm

An. Input Puffing Temp. Broken Cable An. Input Head Temp. Broken Cable An. Input Balance Broken Cable Head Remote Slave X21 Bus FaultHead Remote Slave X22 Bus FaultPneumat. Remote Slave A25 Bus FaultOutlet Roller T. Out AlarmCap Not Detected AlarmSpout Pliers SensorsCapper SensorsSwing Sensors

Steril Chamber Sensors灌装头被打开灌装头温度过低喷汽温度过低超时报警皮重过高报警设定值错误超出误差范围称重故障

称重最大值故障

喷汽温度输入信号故障灌装头温度输入信号故障称重输入信号故障

灌装头远程模块X21总线故障灌装头远程模块X22总线故障气控柜远程模块X23总线故障出口辊道超时报警没有检测到盖子袋夹感应器拔盖感应器摆臂感应器

灌装头盖板感应器

灌装机故障警报显示

故障显示（英文）Cap Detector SensorsDosing Valve SensorsDrum in Pos. Up SensorBins Rise Sensor

Stop Pallet Rise SensorTable Down Sensor0 Degree Table Sensor45 Degree Table SensorStop Pallet UpCap CompensatorBins Presence SensorRoller Sensors

Vertical Positioning Error

Vertical Positioning Fault MemoryVertical Command Table TimeoutRotation Positioning Error

Rotation Positioning Fault MemoryRotation Command Table Timeout

故障显示（中文）有/无盖检测感应器灌注阀感应器桶感应器吨箱感应器

挡托盘上升感应器工作台下降感应器工作台0o感应器

o

工作台45感应器挡托盘上升压盖补偿

吨箱就位感应器吨箱就位感应器升降台位置故障升降台位置出错记忆升降台指令超时旋转台位置故障旋转台位置出错记忆旋转台指令超时